STEAM BOILER OPERATING AND MAINTENANCE MANUAL Prepared by Meksis A.Ş. Service and R&D Department. Address: ASO 2.San. Bölgesi 2009. Cad. No:6 Temelli Türkobası Köyü Sincan / ANKARA/ TURKEY Phone : +90 312 271 43 05 Fax : +90
2017/7/25 · Steam generated at high pressure and superheated would be fed to a turbine driving an alternator to generate electricity. Low-pressure steam leaving the turbine would then be used for the process.The smaller water tube boilers can be built at the manufacturers and delivered to site as one unit package water tube boiler.
10. Prior to lighting off a cold automatically fired auxiliary boiler, you should A. check and regulate the water level B. close the air cock once fires are lit C. blow down the gage glass D. crack the steam stop to assure protective steam flow Answer-A 11. Steam
Boilers, water heaters, water heating and cooling units, and oil heaters are used in the heating of water or oil for use in another process. Boilers transfer heat to a liquid to heat water, heat oil, s have a water feed system, a steam system, and a fuel system. Different types of boilers are: fire tube boiler, water tube boiler, packaged boiler, fluidized bed combustion boiler
2015/3/17 · Steam, Boiler, and Blowdown Pressure are the same. Combustion Efficiency is the % of fuel energy that is directly added to the feedwater and not otherwise lost or used. Blowdown Rate is the % of incoming feedwater mass flow rate that leaves the boiler as a saturated liquid at boiler pressure.
2019/5/22 · The reheater heats the steam (point D) and then the steam is directed to the low-pressure stage of steam turbine, where expands (point E to F). The exhausted steam is at a pressure well below atmospheric, and, as can be seen from the picture, the steam is in a partially condensed state (point F), typically of a quality near 90%, but it is much higher vapor quality, than that it would be
Boiler Economiser: Boiler Economiser ( Sometimes Called Economizer ) is the Energy improving device that helps to reduce the cost of operation by saving the fuel. The economizer in Boiler tends to make the system more energy efficient.In boilers, economizers are generally Heat Exchangers which are designed to exchange heat with the fluid, generally water.
Blowdown in Boiler Definition Blowdown in Boiler, Usually, water which is fed to the boiler contains high Total Dissolved Solids (TDS) content as well as other dissolved and undissolved solids in it. On heating water or converting water to steam, these dissolved solids do not evaporate and gets separated from water or steam and settled at the bottom of the shell.